9 Volts + 9 Volts = bang ! - Electronic Circuits Projects Diagrams Free

RODALCO · 1st May 2008, 09:39 AM

I had to replace two flat 9 Volt multi-meter batteries at work and decided to do the following test and see what happens.

One was down to about 5.5 Volts, while the other was down to around 7.5 Volts.

The test result surprised me. I didn't see them explode but one hour later this was the result.
The batteries were put outside during the test.
One pack completely ruptured, other one intact and holding some voltage.

It does certainly confirm the warnings about explosion danger of batteries.

Warning: if you do the test and decide to see what happens, I strongly recommend that you wear safety goggles and have a transparant piece of PVC or glass to shield yourself from the rupture.
You never know what way these cells may explode.

Regards, Raymond

ericgibbs · 1st May 2008, 10:05 AM

hi,
What was the test.?

RODALCO · 1st May 2008, 10:21 AM

Put + to - and + to - as per first photo.

The circulating current is limited by the batteries internal resistance.

The heating will rupture the casing.

audioguru · 2nd May 2008, 01:46 AM

At work a woman gave a speech to everybody. She had a wireless microphone that fed a PA system.
She began dancing and jumping.
The spare 9V alkaline battery in her pocket was shorted by her keys and was burning her.

Marks256 · 3rd May 2008, 02:36 AM

I used to do this as a kid thinking it would charge the other battery backup... Luckily this never happened to me!

Hero999 · 3rd May 2008, 10:28 PM

If you connected them positive to positive, then that would happen but not positive to negative.

Another thing is sometimes batteries can blow hours after they've been abused. When I was a child I remember connecting a 9V battery to a dead button cell to see what would happen. The button cell didn't rupture immediately but half an hour or so later.

bananasiong · 4th May 2008, 03:05 AM

When I was a kid, I've tried recharging the dead 9 V alkaline. Guess what, I connected the live and neutral to the +ve and -ve of the battery by using transparent tape

.
Then I turn on the main from far and turn off quickly. Smoke coming out

. Luckily there's no one else at home otherwise I got scolded

Thread Tools	Search this Thread
Show Printable Version Email this Page	Search this Thread: Advanced Search
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Thread Starter	Forum	Replies	Latest
How can I get 3 volts to trigger a short circuit??(skateboard timer)	scuppers	Electronic Projects Design/Ideas/Reviews	5	22nd March 2008 11:46 AM
How to turn 0-5 volts to 5-0 volts	Markley02	Electronic Projects Design/Ideas/Reviews	36	22nd December 2007 12:39 AM
Reduce 5 volts to 3 volts, suggestions?	prprog	Electronic Projects Design/Ideas/Reviews	19	21st December 2006 06:02 PM
12 volts from two 9 volt batteries	sandmantoy	Electronic Projects Design/Ideas/Reviews	9	22nd April 2006 01:02 PM
3.7 volts LED with 2 volts	Grimchuck	General Electronics Chat	9	27th April 2003 04:26 PM

1st May 2008, 10:05 AM
ericgibbs Experienced Member	hi, What was the test.? __________________ Eric "Good enough is Perfect" PIC tutorials: Nigel's site: http://www.winpicprog.co.uk/ Gramo's site: http://www.digital-diy.net/

1st May 2008, 10:21 AM
RODALCO Experienced Member	Put + to - and + to - as per first photo. The circulating current is limited by the batteries internal resistance. The heating will rupture the casing. __________________ There are more ways to get to Rome. Electricity, Electric clocks, Meters and Trains are great.

2nd May 2008, 01:46 AM
audioguru Experienced Member	At work a woman gave a speech to everybody. She had a wireless microphone that fed a PA system. She began dancing and jumping. The spare 9V alkaline battery in her pocket was shorted by her keys and was burning her. __________________ Uncle $crooge

3rd May 2008, 02:36 AM
Marks256 Experienced Member	I used to do this as a kid thinking it would charge the other battery backup... Luckily this never happened to me! __________________ There is no "I" in "team", unless Apple makes it... Then it would be iTeam.

3rd May 2008, 10:28 PM
Hero999 Experienced Member	If you connected them positive to positive, then that would happen but not positive to negative. Another thing is sometimes batteries can blow hours after they've been abused. When I was a child I remember connecting a 9V battery to a dead button cell to see what would happen. The button cell didn't rupture immediately but half an hour or so later. __________________ What's so bad about Microsoft? Get Opera it's simply a superb browser.

4th May 2008, 03:05 AM
bananasiong Experienced Member	When I was a kid, I've tried recharging the dead 9 V alkaline. Guess what, I connected the live and neutral to the +ve and -ve of the battery by using transparent tape . Then I turn on the main from far and turn off quickly. Smoke coming out . Luckily there's no one else at home otherwise I got scolded __________________ Superman Returns.. http://www.supermanhomepage.com/imag...an-returns.gif My friend created this account for me.. LOL http://bananasiong.myminicity.com oh.. somemore http://bananasiong.myminicity.com/env Exam T_T.T